-
Scrambler 1000 Bottom End Crankshaft Assembly
New replacement bottom end crankshaft assembly for your Polaris Scrambler 1000! Exact replacement and ready to be dropped into your engine. Does NOT included main bearing or seals. Replaces Polaris Number(s): 2205143.
FITS THE FOLLOWING MODELS:
2015-’22 SCRAMBLER 1000 2014-’22 SCRAMBLER XP 1000 REPLACES POLARIS PART NUMBER(S): 2205143
$999.95$899.96Scrambler 1000 Bottom End Crankshaft Assembly
$999.95$899.96 -
RZR 1000 XP Crankshaft Assembly with Rods
New RZR 1000 XP Crankshaft Assembly. Complete OEM replacement crankshaft assembly. Factory trued and balanced. Includes crankshaft, connecting rods, top end bearings, and crank pins. Ready to install. Stroke73.500 mm.
Fits the following:
2016-21 RZR 1000 60 Inch
2018-19 RZR 1000 60 Inch EPS
2014-21 RZR XP 1000
2014-15 RZR XP 1000 [INTL]
2021-22 RZR XP 1000 Trails & Rocks
2014-21 RZR XP 4 1000
2021-22 RZR XP 4 1000 High LifterReplaces Polaris part numbers: 1204832, 3023103, 3023169
$969.95$872.96RZR 1000 XP Crankshaft Assembly with Rods
$969.95$872.96 -
Scrambler 850 Bottom End Crankshaft Assembly
New replacement bottom end crankshaft assembly for your Polaris Scrambler 850! Exact replacement and ready to be dropped into your engine. Does NOT included main bearing or seals. Replaces Polaris Number(s): 2204233.
FITS THE FOLLOWING MODELS:
2013-’22 Scrambler 850 REPLACES POLARIS PART NUMBER(S): 2204233
$899.95$809.96Scrambler 850 Bottom End Crankshaft Assembly
$899.95$809.96 -
ACE 500 Bottom End Crankshaft Assembly
New replacement bottom end crankshaft assembly for your Polaris ACE 500! Exact replacement and ready to be dropped into your engine. Does NOT included main bearing or seals. Replaces Polaris Number(s): 2206366.
FITS THE FOLLOWING MODELS:
2017-’19 ACE 500 REPLACES POLARIS PART NUMBER(S): 2206366
$739.95$665.96ACE 500 Bottom End Crankshaft Assembly
$739.95$665.96 -
Ranger 700 Bottom End Crankshaft Assembly
New replacement bottom end crankshaft assembly for your Polaris Ranger 700. Exact replacement and ready to be dropped in to your engine. Does not include main bearings or seals. Replaces Polaris 2203067.
FITS THE FOLLOWING MODELS:
2007-’09 Ranger 700Replaces Polaris Part Number(s): 2203067
$719.95$647.96Ranger 700 Bottom End Crankshaft Assembly
$719.95$647.96 -
Ranger 800 Bottom End Crankshaft Assembly
New replacement bottom end crankshaft assembly for your Polaris RZR, Sportsman, and Ranger 800. Exact replacement and ready to be dropped in to your engine. Does not include main bearings or seals. Replaces Polaris 2205112, 2202916, and 2203068.
FITS THE FOLLOWING MODELS:
2010-’16 RANGER 800 2010-’14 RANGER CREW 800 2012 RANGER XP 800 REPLACES POLARIS PART NUMBER(S): 2205112, 2202916, and 2203068
$699.95$629.96Ranger 800 Bottom End Crankshaft Assembly
$699.95$629.96 -
Ranger 900 SPLYT Technology Stator and Voltage Regulator Kits
The stock RZR 1000 voltage regulators are terrible. They are a known problem and can easily burn out from excess heat, especially when using high amperage accessories. Do not replace it with another OEM unit! SPLYT Technology provides a reliable solution to well-known charging system failures. Using a dual output stator with two completely separate stator windings, this system splits the power generated by the stator into two separate voltage regulators. These regulators then each operate with only half of the load of the original system, allowing them to maintain a lower temperature and increase reliability.
For people with large subs or light bars there is also the kit with an upgraded flywheel. This charging upgrade provides a tremendous 900W output to allow you to install accessories without draining the original battery nor installing a secondary battery. This upgrade installs seamlessly freeing the space a second battery would take on your ride. Replaces Polaris part number 4014029, 4013247, 4013904, 4014029, 4016868, 4014856, and 4015229.
Fits all 2013-18 Ranger 900 XP
Replaces Polaris Part Numbers: 4014029, 4013247, 4013904, 4014029, 4016868, 4014856, and 4015229
$499.95 – $649.95
$449.96 – $584.96 -
Ranger 1000 SPLYT Technology Stator and Voltage Regulator Kits
The stock RZR 1000 voltage regulators are terrible. They are a known problem and can easily burn out from excess heat, especially when using high amperage accessories. Do not replace it with another OEM unit! SPLYT Technology provides a reliable solution to well-known charging system failures. Using a dual output stator with two completely separate stator windings, this system splits the power generated by the stator into two separate voltage regulators. These regulators then each operate with only half of the load of the original system, allowing them to maintain a lower temperature and increase reliability.
For people with large subs or light bars there is also the kit with an upgraded flywheel. This charging upgrade provides a tremendous 900W output to allow you to install accessories without draining the original battery nor installing a secondary battery. This upgrade installs seamlessly freeing the space a second battery would take on your ride. Replaces Polaris part number 4014029, 4013247, 4013904, 4014029, 4016868, 4014856, and 4015229.
Fits all 2017-18 Ranger 1000
Replaces Polaris Part Numbers: 4014029, 4013247, 4013904, 4014029, 4016868, 4014856, and 4015229
$499.95 – $649.95
$449.96 – $584.96 -
Polaris Sportsman 570 NEW Crankshaft Crank Assembly
Brand new crankshaft assembly for your Polaris Sportsman 570. Connecting rod and is ready to be dropped in to your engine.
Does not include seals.
Polaris part number 2204729.
Fits the following models:
2014-16 Sportsman 570
2017 Sportsman 570 6×6
2014-16 Sportsman 570 EPS
2015-16 Sportsman 570 SP
2015-16 Sportsman 570 SP EPS
2015-16 Sportsman 570 X2 EPS
2014-15 Sportsman Touring 570
2015-16 Sportsman Touring 570 EPS
2015-16 Sportsman Touring 570 SPShipping from Ramsey, Minnesota (USA) within 24 hours allows you to BUY WITH CONFIDENCE!
$599.95$539.96Polaris Sportsman 570 NEW Crankshaft Crank Assembly
$599.95$539.96 -
Polaris RZR 16 Turbo BMP PROGRAMMED POWER VISION CX
DynoJet Power Vision CX Tuner with BMP Custom Tuning for all 2016 Polaris RZR XP Turbo models
Level 1 – 91 Octane – 130 RWHP (+25 RWHP over stock)
Level 2 – 91 Octane – 140 RWHP (+35 RWHP over stock)
Device Features:
- Flash performance tunes via OEM diagnostic connector, no need to remove and send out ECU
- Display vehicle data channels in real-time
- Weather resistant for use in all conditions
- High contrast display, visible in direct sunlight
BMP Performance Tunes:
- Fueling revised for maximum power and torque – extreme horsepower gains with our highly advanced custom tuning!
- Spark timing optimized for 91 octane fuel
- Rev limit raised in high and low gears to 9000 RPM
- Speed limit raised in high and low gears to 96 MPH
- Torque limiting functions reduced or eliminated
- Throttle limiters eliminated
- Revised drive-by-wire throttle profiles for high and low gears
- Lower fan turn-on temps of 183 degrees
- Seat belt limiter disabled
- Left foot brake mode enabled
- No overboost codes
- Retains ADC and Turf mode where applicable
- Boost control for Turbo models
$500.00
$450.00Polaris RZR 16 Turbo BMP PROGRAMMED POWER VISION CX
$500.00
$450.00 -
Polaris RZR 900 XP (2011-2014) Cylinder – Standard Bore
This new cylinder is designed to match the OEM in appearance and specifications. No case modifications needed when installing. Just unbolt the original cylinder, bolt on this new one, drop your pistons in and you are good to go. Made from AB4C aluminum with Nikasil plated sleeves for excellent wear and durability.
Replaces Polaris part number(s): 3022278
FITS THE FOLLOWING MODELS:
2011-’14 RZR 900 XP
2012-’14 RZR 4 900Shipping from Ramsey, Minnesota (USA) within 24 hours allows you to BUY WITH CONFIDENCE!
$499.95$449.96Polaris RZR 900 XP (2011-2014) Cylinder – Standard Bore
$499.95$449.96 -
RZR 1000 XP (2014-2021) Cylinder
This new cylinder is designed to match the OEM in appearance and specifications. No case modifications needed when installing. Just unbolt the original cylinder, bolt on this new one, drop your pistons in and you are good to go. Made from AB4C aluminum with Nikasil plated sleeves for excellent wear and durability.
Replaces Polaris part number(s): 3022594, 3022523, 3023156
FITS THE FOLLOWING MODELS:
2014-21 RZR 1000 XP (Choose year at drop down)Shipping from Ramsey, Minnesota (USA) within 24 hours allows you to BUY WITH CONFIDENCE!
$399.95
$359.96RZR 1000 XP (2014-2021) Cylinder
$399.95
$359.96 -
RZR 1000 XP Performance Oil Cooler
Are you sick of over heating issues or like to push your machine to the limits? Help your machine stay 20% cooler with our aftermarket Quad Logic oil cooler. This complete bolt on kit that utilizes the OEM water to oil cooler for double the cooling power. Increases your oil capacity and extends your oil life with Smart Cooling. This product is designed to bolt onto the back of your roll cage and has heavy duty 6061 billet mounting brackets to with stand the toughest conditions while still looking good.
- 16 Row oil cooler
- Adapter plate made out of 6061 aluminum
- Left and Right mounting brackets made out of 6061 aluminum for oil cooler
- Two high temp nylon braided lines
Fits the following:
2014-20 RZR XP 1000
$399.95$359.96RZR 1000 XP Performance Oil Cooler
$399.95$359.96 -
Polaris Sportsman 800 New Cylinder – Standard Bore
Brand new OEM spec direct replacement cylinder. Just unbolt the original cylinder, bolt on this new one, drop your pistons in and you are good to go.
Replaces Polaris part numbers 2202696 and 2204393
Fits the following models:
2005-’14 SPORTSMAN 800
2011-’14 SPORTSMAN 800 6×6
2008 SPORTSMAN TOURING 800
2007-’08 SPORTSMAN X2 800Shipping from Ramsey, Minnesota (USA) within 24 hours allows you to BUY WITH CONFIDENCE!
$399.95$359.96Polaris Sportsman 800 New Cylinder – Standard Bore
$399.95$359.96 -
ACE 900 Cylinder
This new ACE 900 cylinder is designed to match the OEM in appearance and specifications. No case modifications needed when installing. Just unbolt the original cylinder, bolt on this new one, drop your pistons in and you are good to go. Made with Nikasil plated sleeves for excellent wear and durability.
Replaces Polaris part number(s): 3022442, 3022579
FITS THE FOLLOWING MODELS:
2016 ACE 900 EPS
$399.95$359.96ACE 900 Cylinder
$399.95$359.96 -
Sportsman 600 Magneto Flywheel
Complete new replacement flywheel for your Polaris Sportsman 600/700. This flywheel is the same as OEM from the original supplier, this is NOT a reproduction! Installation is just like stock. Replaces Polaris part number 4060152. Fits the following models:
2003-04 Sportsman 600 (2004 models only built before 02/23/2003)
We make every attempt to ensure every items fitment is accurate. We do the testing on each item before its listed for sale to ensure fitment and quality. Items may fit multiple years and models listed.
Returns are subject to 15% restocking fee.
$319.95$287.96Sportsman 600 Magneto Flywheel
$319.95$287.96
- HOME
- Quad-Logic ATV Parts
- POLARIS RZR PARTS AND ACCESSORIES
- Polaris RZR 570 Parts and Accessories
- Polaris RZR 800 Parts and Accessories
- Polaris RZR 900 XP Parts and Accessories
- Polaris RZR 1000 XP Parts and Accessories
- Polaris RZR 1000 S Parts and Accessories
- Polaris RZR 900 Trail/XC/S Parts and Accessories
- RS1 Parts and Accessories
- RZR PRO XP
- Polaris RZR Turbo Parts and Accessories
- POLARIS RANGER PARTS AND ACCESSORIES
- POLARIS ATV PARTS AND ACCESSORIES
- Sportsman 400
- Polaris Sportsman 500 Parts and Accessories
- Polaris Sportsman 570 Parts and Accessories
- Polaris Sportsman 600 Parts and Accessories
- Polaris Sportsman 700 Parts and Accessories
- Polaris Sportsman 800 Parts and Accessories
- Polaris Sportsman 550/850/1000 XP Parts and Accessories
- Polaris Scrambler 500 Parts and Accessories
- Polaris Scrambler 850/1000 Parts and Accessories
- Polaris Trailblazer Parts and Accessories
- Polaris Magnum Parts and Accessories
- Polaris Ace Parts and Accessories
- CAN-AM PARTS AND ACCESSORIES
- POLARIS RZR PARTS AND ACCESSORIES
- ATV
- UTV
- SNOWMOBILE
- MOTORCYCLE
- LAWN & GARDEN
- Small Engine Parts
- 50% OFF PRODUCTS
- Checkout